Torque Curves for a Three-Phase Induction Motor Operating a Fan

​
rotor resistance [ohms]
0.658
stator voltage [V]
220
frequency [Hz]
50
This Demonstration shows superimposed plots of the torque curves of a three-phase induction motor and that of a connected ventilation fan.
The intersection of the two curves is highlighted to show the operating point for each set of parameters, that is, the torque and the speed at which the fan-motor assembly turns for different rotor resistances and power supply conditions.

Details

The IV-pole, 5.5-kW, 11.7-A, 50-Hz motor has the following equivalent circuit parameters referred to the stator:
- Stator resistance:
R
1
=0.94ohms
- Stator leakage reactance:
X
1
=1.598ohms(@50Hz)
- Rotor resistance:
R
2
=0.658ohms
- Rotor leakage reactance:
X
2
=1.598ohms(@50Hz)
- Magnetizing branch reactance:
X
m
=32.54ohms(@50Hz)
- The parallel branch resistance is neglected.
The fan is supposed to draw exactly 5.5 kW from the motor (the motor's rated power) at its rated speed. For simplicity, the fan torque curve is adjusted using a quadratic fit starting at
(0,0)
.
You can vary the voltage applied to the motor to show the corresponding torque-axis variation of the motor's torque curve. You can also vary the current frequency between 50 Hz and 60 Hz, which clearly changes the synchronous speed (intersection of the motor's torque curve with the speed axis) along with the horizontal shape of the motor's torque curve.
Additionally, you can vary the rotor resistance
R
2
over a wide range to show the impact of this design parameter on the motor's performance.
The area of the shaded rectangle represents the mechanical power transferred from the motor to the fan at the corresponding operating conditions. It is of particular interest to compare the visible increase in the mechanical power when the supply frequency is switched from 50 Hz to 60 Hz.

References

[1] S. Chapman, Electric Machinery Fundamentals, 4th ed., New York: McGraw–Hill, 2005.

Permanent Citation

Diego M. Ferreyra
​
​"Torque Curves for a Three-Phase Induction Motor Operating a Fan"​
​http://demonstrations.wolfram.com/TorqueCurvesForAThreePhaseInductionMotorOperatingAFan/​
​Wolfram Demonstrations Project​
​Published: October 20, 2013